|
|
|
|||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||
Phosphoric acid |
CAS 7664-38-2 | ||
H3PO4 |
RTECS TB6300000 | ||
|
Synonyms & Trade Names Orthophosphoric acid, Phosphoric acid (aqueous), White phosphoric acid |
DOT ID & Guide 1805 154 (liquid or solution) 3453 154 (solid) |
||
Exposure
|
NIOSH REL: TWA 1 mg/m3 ST 3 mg/m3 | ||
| OSHA PEL†: TWA 1 mg/m3 | |||
| IDLH 1000 mg/m3 See: 7664382 | Conversion | ||
|
Physical Description Thick, colorless, odorless, crystalline solid. [Note: Often used in an aqueous solution.] |
|||
|
MW: 98.0 |
BP: 415°F |
MLT: 108°F |
Sol: Miscible |
|
VP: 0.03 mmHg |
IP: ? |
|
Sp.Gr(77°F): 1.87 (pure) 1.33 (50% solution) |
|
Fl.P: NA |
UEL: NA |
LEL: NA |
|
| Noncombustible Solid | |||
|
Incompatibilities & Reactivities Strong caustics, most metals [Note: Readily reacts with metals to form flammable hydrogen gas. DO NOT MIX WITH SOLUTIONS CONTAINING BLEACH OR AMMONIA.] |
|||
|
Measurement Methods NIOSH 7903; OSHA ID165SG See: NMAM or OSHA Methods |
|
Personal Protection & Sanitation (See protection) Skin: Prevent skin contact Eyes: Prevent eye contact Wash skin: When contaminated Remove: When wet or contaminated Change: Daily Provide: Eyewash (>1.6%), Quick drench (>1.6%) |
First Aid (See procedures) Eye: Irrigate immediately Skin: Water flush immediately Breathing: Respiratory support Swallow: Medical attention immediately |
|
Important additional information about respirator selection Respirator Recommendations NIOSH/OSHA Up to 25 mg/m3: (APF = 25) Any supplied-air respirator operated in a continuous-flow mode* Up to 50 mg/m3: (APF = 50) Any air-purifying, full-facepiece respirator with an N100, R100, or P100 filter. Click here for information on selection of N, R, or P filters. (APF = 50) Any self-contained breathing apparatus with a full facepiece (APF = 50) Any supplied-air respirator with a full facepiece Up to 1000 mg/m3: (APF = 2000) Any supplied-air respirator that has a full facepiece and is operated in a pressure-demand or other positive-pressure mode Emergency or planned entry into unknown concentrations or IDLH conditions: (APF = 10,000) Any self-contained breathing apparatus that has a full facepiece and is operated in a pressure-demand or other positive-pressure mode (APF = 10,000) Any supplied-air respirator that has a full facepiece and is operated in a pressure-demand or other positive-pressure mode in combination with an auxiliary self-contained positive-pressure breathing apparatus Escape: (APF = 50) Any air-purifying, full-facepiece respirator with an N100, R100, or P100 filter. Click here for information on selection of N, R, or P filters./Any appropriate escape-type, self-contained breathing apparatus |
|
| Exposure Routes inhalation, ingestion, skin and/or eye contact | |
| Symptoms Irritation eyes, skin, upper respiratory system; eye, skin, burns; dermatitis | |
|
Target Organs
Eyes, skin, respiratory system |
|
| See also: INTRODUCTION See ICSC CARD: 1008 |